活性炭吸附和两级Fenton氧化组合工艺处理高盐对氨基苯酚生产废水

采用活性炭吸附和两级Fenton氧化组合工艺对高盐度对氨基苯酚生产废水进行了处理实验研究。结果表明,p H值对活性炭去除有机物的影响较小。当活性炭投加量为4 g/L时,TOC去除率61%。分级加药可以有效提高Fenton氧化对有机物的去除效率。在温度为25℃、p H为3、30%H2O2投加量为3%(V/V)、Fe2+/H2O2摩尔比为0.05时,两级Fenton氧化处理后,出水TOC降至150 mg/L以下。此外,Fenton氧化后形成氢氧化铁污泥颗粒粒径为4.5μm,经过聚丙烯酰胺(PAM)絮凝之后,污泥的粒径明显增加,过滤特性改善。PAM絮凝效果依赖于溶液的p H值,当p H超过10后会失去作用,故在使用过程中需要严格控制溶液的p H值。     

Enhanced sludge solubilization by microbubble ozonation

A microbubble ozonation process for enhancing sludge solubilization was proposed and its performance was evaluated in comparison to a conventional ozone bubble contactor. Microbubbles are defined as bubbles with diameters less than several tens of micrometers. Previous studies have demonstrated that microbubbles could accelerate the formation of hydroxyl radicals and hence improve the ozonation of dyestuff wastewater. The results of this study showed that microbubble ozonation was effective in increasing ozone utilization and improving sludge solubilization. For a contact time of 80 min, an ozone utilization efficiency of more than 99% was obtained using the microbubble system, while it gradually decreased from 94% to 72% for the bubble contactor. The rate of microbial inactivation was obviously faster in the microbubble system. At an ozone dose of 0.02 g O₃ g⁻¹ TSS, about 80% of microorganisms were inactivated in the microbubble system, compared with about 50% inactivation for the bubble contactor. Compared to the bubble contactor, more than two times of COD and total nitrogen, and eight times of total phosphorus content were released from the sludge into the supernatant by using the microbubble system at the same ozone dosage. The application of microbubble technology in ozonation processes may provide an effective and low cost approach for sludge reduction.     

Relationships between anaerobic consortia and removal efficiencies in an UASB reactor degrading 2,4 dichlorophenol (DCP)

To gain more insight into the interactions between anaerobic bacteria and reactor performances (chemical oxygen demand-COD, 2,4 dichlorophenol-2,4 DCP removals, volatile fatty acid-VFA, and methane gas productions) and how they depended on operational conditions the microbial variations in the anaerobic granular sludge from an upflow anaerobic sludge blanket (UASB) reactor treating 2,4 DCP was studied. The study was composed of two parts. In the first part, the numbers of methanogens and acedogens in the anaerobic granular sludge were counted at different COD removal efficiencies. The relationships between the numbers of methanogens, the methane gas production and VFA production were investigated. The COD removal efficiencies increased to 74% from 30% while the number of total acedogens decreased to 10 from 30 cfu ml(-1). The number of total methanogens and acedogens varied between 11 x 10(3) and 10 x 10(9)MPN g(-1) and 10 and 30 cfu ml(-1) as the 2,4 DCP removal efficiencies were obtained between 60% and 99%, respectively. It was seen that, as the number of total acedogens decreased, the COD removal efficiencies increased. However, the number of total methanogens increased as the COD removal efficiencies increased. Correlations between the bacterial number and with the removal efficiencies obtained in different operational conditions were investigated. From the results presented in this paper a high correlation between the number of bacteria, COD removals, methane gas percentage, 2,4 DCP removals and VFA was observed. In the second part, methanogen bacteria in the anaerobic granular sludge were identified. Microbial observations and biochemical tests were applied to identify the anaerobic microorganisms from the anaerobic granular sludge. In the reactor treating 2,4 DCP, Methanobacterium bryantii, Methanobacterium formicicum, Methanobrevibacter smithii, Methanococcus voltae, Methanosarcina mazei, Methanosarcina acetivorans, Methanogenium bourgense and Methanospirillum hungatei were identified.     

上海城市污水厂污泥处理与利用系统分析

上海市城市污水处理规划的实施，将在2020年前使该市的城市污水厂污泥产生量从现状的85tDS/d增长至1300－1500tDS/d，将形成可观的污泥消纳压力。预期了该市的污水污泥产生状况，以现有污水污泥处置与利用技术为基础，测算了可行的污泥处置与利用方向及相应的容量，以及满足容量利用的前处理要求。以此为基础，推荐了适宜的容量利用方案，并建议以生物稳定化干化处理为污泥处置与利用前的改性处理步骤，且可在适当的条件下增加厌氧消化环节，提高处理体系的水平与容量宽余度。此污泥处理与利用体系可达到污泥消纳运行的柔性化和可靠性，兼具环境安全性与经济合理性。     

Immersion frying for the thermal drying of sewage sludge: an economic assessment

This paper presents an economic study of a novel thermal fry-drying technology which transforms sewage sludge and recycled cooking oil (RCO) into a solid fuel. The process is shown to have significant potential advantage in terms of capital costs (by factors of several times) and comparable operating costs. Three potential variants of the process have been simulated and costed in terms of both capital and operating requirements for a commercial scale of operation. The differences are in the energy recovery systems, which include a simple condensation of the evaporated water and two different heat pump configurations. Simple condensation provides the simplest process, but the energy efficiency gain of an open heat pump offset this, making it economically somewhat more attractive. In terms of operating costs, current sludge dryers are dominated by maintenance and energy requirements, while for fry-drying these are comparatively small. Fry-drying running costs are dominated by provision of makeup waste oil. Cost reduction could focus on cheaper waste oil, e.g. from grease trap waste.     

Fate of cancerostatic platinum compounds in biological wastewater treatment of hospital effluents

The present work focuses on the fate of two cancerostatic platinum compounds (CPC), cisplatin and carboplatin, as well as of two inorganic platinum compounds, [PtCl₄]²⁻ and [PtCl₆]²⁻ in biological wastewater treatment. Laboratory experiments modelling adsorption of these compounds onto activated sludge showed promising specific adsorption coefficients K_D and K_OC and Freundlich adsorption isotherms. However, the adsorption properties of the investigated substances were differing significantly. Adsorption decreased following the order cisplatin > [PtCl₆]²⁻ > [PtCl₄]²⁻ > carboplatin. Log K_D-values were ranging from 2.5 to 4.3 , log K_OC from 3.0 to 4.7.

A pilot membrane bioreactor system (MBR) was installed in a hospital in Vienna and fed with wastewater from the oncologic in-patient treatment ward to investigate CPC-adsorption in a sewage treatment plant. During three monitoring periods Pt-concentrations were measured in the influent (3–250 μg l⁻¹ Pt) and the effluent (2–150 μg l⁻¹ Pt) of the treatment plant using ICP-MS. The monitoring periods (duration 30 d) revealed elimination efficiencies between 51% and 63% based on averaged weekly input–output budgets. The derived log K_D-values and log K_OC-values ranged from 2.4 to 4.8 and from 2.8 to 5.3, respectively. Species analysis using HPLC-ICP-MS proofed that mainly carboplatin was present as intact drug in the influent and – due to low log K_D – in the effluent of the MBR.     

污泥加热预处理对中温厌氧消化的影响

对污泥加热预处理给中温厌氧混合消化和污泥单独消化带来的影响进行了研究.研究结果表明,污泥加热预处理有利于提高混合消化对 COD 的去除率,尤其是 SCOD 的去除率由 77%增长到 93%,但不利于 TS 和 VS 的去除;而对污泥单独消化,预处理则不利于有机物的去除.采用加热预处理后的污泥进样,混合消化和污泥单独消化的甲烷产气量均有所提高.     

死菌DNA对厌氧消化污泥中抗生素抗性基因及微生物群落分析的干扰

为评估死菌DNA对厌氧消化污泥抗生素抗性基因(ARGs)和微生物群落分析的潜在干扰,本研究对3种不同类型厌氧消化污泥进行叠氮溴化丙锭(PMA)处理,比较在PMA屏蔽死菌DNA PCR扩增情况下污泥ARGs和微生物群落分析结果与未经PMA处理情况下的差异.结果表明,经PMA处理后,剩余污泥自厌氧消化样品和高含固厌氧消化污泥样品中的ARGs丰度分别下降了41%～86%和74%～98%;污泥水解液厌氧消化15 d后的污泥样品中ARGs下降幅度相对较小,但降幅最高也达到34%.PMA处理对3个来源不同的厌氧消化污泥微生物群落组成分析结果呈现不同程度的影响,对高含固厌氧消化污泥的微生物群落结构分析影响最为显著.在经PMA处理与未经PMA处理两种情况下,厌氧消化污泥ARGs与微生物群落组成相关性分析的结果也截然不同.研究证明了死菌DNA对厌氧消化污泥ARGs和微生物群落分析的潜在干扰,采用PMA预处理能够更准确地反映厌氧消化污泥中的微生物群落及菌体携带ARGs的特征.     

低温下丝状菌膨胀污泥的微生物多样性

为探究低温下丝状菌污泥膨胀过程中微生物多样性的变化特征,实验采用低温-SBR反应器成功诱发污泥膨胀,并借助Illumina MiSeq高通量测序技术,考察了不同沉降性能下活性污泥微生物群落的整体变化特征、各特定菌群及特定菌属的变化特征.结果表明,在系统运行温度降至(14±1)℃后可成功诱发丝状菌污泥膨胀,SVI可恶化至663.99 mL·g~(-1),且膨胀后COD去除率和TN去除率仍能维持在90%和86%左右.低温下污泥膨胀的发生不仅会导致系统内微生物整体多样性和均一性的降低,使特定菌群中丝状菌群的丰度由0.49%增至26.04%,还会使脱氮菌群的丰度由21.04%减少至13.99%、除磷菌群的丰度由4.25%减少至1.93%.发现的5种丝状菌属中,以Thiothrix为代表的3种菌属的丰度递增,仅Haliscomenobacter的丰度递减;发现的19种脱氮菌属中,以Nitrosomonas为代表的5种菌属的丰度递增,以Nitrospira为代表的7种菌属的丰度递减;发现的8种除磷菌属中,Pseudomonas和Tetrasphaera的丰度递增,以Candidatus_Competibacter为代表的5种菌属的丰度递减.虽然污泥膨胀对微生物菌群结构产生较大影响,但不同泥样中始终存在的477个OTUs和227个菌属说明膨胀过程中反应器内主体微生物仍呈相对稳定状态.     

基于不同废污泥源的短程反硝化快速启动及稳定性

为探究不同废污泥源快速启动短程反硝化和实现稳定NO_2~--N积累的可行性,在3个完全相同的SBR反应器(S1、S2和S3)分别接种:实验室城市污水反硝化除磷系统排泥、城市污水厂剩余污泥及河涌底泥,比较其短程反硝化启动快慢和NO_2~--N积累特性,考察系统短程反硝化活性和NO_3~--N→NO_2~--N转化性能,并从微生物学角度分析反应器功能菌群特征.结果表明,在乙酸钠为唯一碳源、高碱度和适宜COD/NO_3~--N比进水条件下,3个SBR短程反硝化反应器在短时间内均能够成功启动,系统平均NO_3~--N→NO_2~--N转化率为S1 S2 S3(75. 92% 73. 36% 69. 90%).同时发现持续低温条件下S1和S2呈现不同程度的短程反硝化性能恶化趋势,但S3能够稳定维持良好NO_2~--N积累性能.微生物高通量测序表明,变形菌门和拟杆菌门居PD系统主导地位,3个短程反硝化反应器NO_2~--N积累关键功能菌属Thauera属丰度差异明显:S3 S1 S2(25. 09% 4. 71% 3. 60%),表明S3具备稳定高效的NO_2~--N积累性能,同时高丰度Thauera属可能是维持低温短程反硝化活性的重要原因.